Dacor Dishwasher Wartungshandbuch

Dishwasher Service Manual69Troubleshooting and Repair

Dishwasher Service ManualTroubleshooting and Repair789. Floor Guard Switch• To remove the oor guard switch, remove the two Phillips screws from the

Dishwasher Service ManualTroubleshooting and Repair7910. Sump RemovalTo remove the sump: • Remove the upper sump collar by turning it counterclockwi

Dishwasher Service ManualTroubleshooting and Repair80 11. Water Valve RemovalTo remove the water valve:• Turn water supply OFF to dishwasher.• Acces

Dishwasher Service ManualTroubleshooting and Repair81Door Components12. Separating the Door To separate the inner and outer door assemblies: • Remov

Dishwasher Service ManualTroubleshooting and Repair8213. MembraneTo change the membrane, rst separate the inner and outer door assemblies. • Remove

Dishwasher Service ManualTroubleshooting and Repair8314. Door Switch RemovalTo remove the door switch: • Separate the inner and outer door. • Re

Dishwasher Service ManualTroubleshooting and Repair8415. Control Board RemovalThe control panel is accessed by separating the inner and outer door ass

Dishwasher Service ManualTroubleshooting and Repair85Inner Tank Components16. Filters • The large outer lter is held in place by the smaller inner

Dishwasher Service ManualTroubleshooting and Repair86To remove the lower spray arm: • Remove the securing nut and washer from the top center portio

Dishwasher Service ManualTroubleshooting and Repair8719. Upper Rack Removal To remove the upper rack: • Pull the rack all the way out of the unit.

Dishwasher Service Manual70Troubleshooting and RepairLower Component Access1. Toe Kick Panel• Remove outer, toe kick (on ED models), (#1a) by pullin

Dishwasher Service ManualTroubleshooting and Repair8821. Detergent Cup Removal To remove the detergent cup: • Gain access to the inside of the door

Dishwasher Service Manual89Troubleshooting and Repair

Dishwasher Service Manual90Troubleshooting and RepairFactory Test Mode:The factory test mode, or FTM, is run on each unit during nal QC to ensure tha

Dishwasher Service Manual91Troubleshooting and RepairCONTROLLER FAILURE CODESFAULT CAUSE EFFECT SOLUTIONDrain Pressure Switch is in the closed positio

92COMPONENT OVERVIEW AND TROUBLESHOOTING BEFORE SERVICING, UNPLUG UNIT. USE EXTREME CAUTION WHEN SERVICING THE BASE COMPONENTS. THE EXTERNAL BODY

9325 deg. Close the soap door and retest. Replace the dispenser if faulty.If the user complains of water spotting and drying difculties, the unit may

94FAULT CAUSE EFFECT SOLUTIONIf the pump appears to be operating normally yet water is left stand-ing in the tank Kinked Hose Pump runs but very littl

95 The red LED will be illuminated if a “Drain” or “Water in Base Pan” failure is detected. See page 69 for description of failure codes.Floor Guard F

96Inline Water HeaterUSE EXTREME CAUTION WHEN SERVICING THE INLINE WATER HEATER. THE EXTERNAL BODY OF THE HEATER WILL BECOME VERY HOT WHEN ENERGIZED.

97Pressure SwitchThe pressure switch is mounted to front of the sump, located in the lower base area. A small hose connects the pressure switch to the

Dishwasher Service Manual71Troubleshooting and Repair2. Heater RemovalUse extreme caution when servicing the base components. The external body of th

Dishwasher Service ManualTroubleshooting and Repair723. Circulation Pump Removal • The circulation pump can be removed two ways: • From the fr

Dishwasher Service ManualTroubleshooting and Repair734. Removing Back Panel • Pull DW from Cabinet. • Remove the rear access panel to allow servi

Dishwasher Service ManualTroubleshooting and Repair745. Circ-Sump Assembly RemovalAll of the components can be removed as an assembly for ease of serv

Dishwasher Service ManualTroubleshooting and Repair756. Removing WPS Sensor & Pressure SwitchThe WPS sensor is mounted to the front of the sump wi

Dishwasher Service ManualTroubleshooting and Repair767. Float Assembly RemovalIf the Styrofoam oat becomes damaged and needs replacement: • Pull th

Dishwasher Service ManualTroubleshooting and Repair778. Drain Pump Removal • Disconnect hoses and wiring from pump. • Pull pump and bracket away fro